DEPARTMENT OF PHYSICS, OREGON STATE UNIVERSITY

LABORATORY SAFETY

 

These instructions apply to research and teaching labs alike.  There are also general safety issues that relate to classroom instruction.  Accidents rarely happen, but when they do, it is important that you are prepared.  Review this information before your first laboratory or recitation section:

  1. Emergency phone numbers:
    The site http://oregonstate.edu/dept/security/emergency_info/emergency_numbers.php has a list of emergency numbers that you can download to keep.   Here is a partial list:

                                                  911 from campus telephones reaches Corvallis emergency.

                                                           737-7000:        Campus emergencies or escort to car or dorm.
                                                           737-3010:        OSU police at OSU
                                                           737-5000:        Saferide program
                                                           766-6924:        Corvallis Police
                                                           766-6857:        Benton County Sheriff

737-xxxx are OSU campus numbers and are reached by dialing 7-xxx from campus phones.  Dial 9 before dialing non-campus local numbers (but not before 911).

Make sure you can give directions to the Physics department and to the particular lab you are in.  Weniger Hall is located on Monroe Avenue and SW Memorial Place.  It is the tallest building on Monroe and easily visible.  The doors closest to most labs are the southeast exit to the parking lot between Weniger Hall and Gilbert Hall, and the southwest exit to the street (Memorial Place) between Weniger Hall and the Student Health Center.

  1. Locate exits and know evacuation routes in the event of earthquake, fire alarm or power outage.  In the event of such an emergency, immediately order students to cease work, and leave the building without gathering personal belongings.
  2. Do NOT leave laboratories unattended under any circumstances while students are there.  Accidents happen suddenly.
  3. No food or drink in the lab.  This protects the equipment from damage, and keeps the equipment and the room clean.  Students can step outside to eat or drink if they need to.
  4. Locate circuit breakers in each laboratory.  Locate fire alarms in the hallways.
  5. First Aid Kit in grad student mail room (WGR 385), and in lab prep room (WGR 202) accessible from the labs WGR 200, 204, 234, 258. The Student Health Center is across from Weniger on the west side (Plageman Hall).
  6. Astronomy labs sometimes involve viewing from the Weniger roof.  Pay particular attention that students do not wander near the edge of the roof.  There is a barrier, but they can defeat it if they try.  Always have your roof key with you – the roof door locks behind you and you need a key to enter and exit the roof.  Never leave students unattended on the roof.
  7. Find out from the course instructor whether any labs have particular safety hazards: high voltage or current, radioactivity, chemicals, heat, lasers.  Appropriate instructions should be given to the students.  Jim Ketter knows everything about undergrad teaching labs - make sure you know who he is.
  8. Special regulations exist for labs in which ionizing radiation is present.  In general, these labs have restricted access, and entry is allowed only after a course from the Radiation Safety office, after which you are issued a photo badge.  No undergraduate teaching labs involve such restrictions, but there is one PH314 lab involving low-level radioactive decay.  The TA will be required to attend radiation training, but the levels are so low that no badges are required.
  9. University insurance does not cover injuries to unauthorized people in the lab - your children, family and friends.  Show them around the lab, by all means, but make sure that no unauthorized person is there without strict supervision.
  10. There are extensive documents concerning all aspects of safety at the OSU Environmental and Health Safety website.

http://oregonstate.edu/dept/ehs/index.html

A few that may be particularly relevant are listed here:

OSU Chemical Hygiene Plan      http://oregonstate.edu/dept/ehs/chyp/chyp.html

Section 1 - General Safety Rules           http://oregonstate.edu/dept/ehs/saferule/safrul1.html

Section 2 - Classroom Safety      http://oregonstate.edu/dept/ehs/saferule/safrul2.html

Section 16 - Lab. Safety Rules  http://oregonstate.edu/dept/ehs/saferule/safrul16.html

  1. Personal safety.  As you travel to and from a lab or recitation section, especially in the evening, be aware of your surroundings and take all reasonable precautions that you would in any city.  Travel with someone else if possible, park your car close to the building, and carry a cell phone.  Use the Saferide program.  Corvallis is a safe community by national standards, but serious assaults on campus and in the wider community have occurred.